investigation on concrete with stone crusher dust as fine aggregate

  • Investigations on concrete with stone crusher dust as fine ...

    The investigations indicate that stone crusher dust has a good potential as fine aggregate in concrete construction. Crusher dust not only reduces

    Chat Online
  • Study On Concrete With Stone Crusher Dust As Fine

    2014-2-28 · Concrete designated as Mix A ( 1 : 1.40 : 3.5, w/c = 0.54) with river sand as fine aggregate, and Mix B ( 1 : 1.6 : 3.5; w/c = 0.53) with stone crusher dust were used in the investigations, Table3. the mix proportions were based on IS 10262 : 1982 and SP 23 : 1982 for M 20 grade concrete with a target strength of 24 MPa.

    Chat Online
  • Study On Concrete With stone Dust - Seminars Topics

    2017-7-1 · The investigation done by Student on the use of stone crusher dust in concrete as an alternative to fine aggregate are presented in this report. Standard concrete cubes (150 mm), cylinders (150x300 mm), prisms (100x100x500 mm) as well as beams (120x150x1350 mm) were tested. The physical properties of stone dust and its influence on the strength ...

    Chat Online
  • Investigation on Waste Plastic Fibre Reinforced Concrete ...

    2020-9-21 · investigations on concrete mixes with stone crusher dust as fine aggregate. They conclude stone crusher dust has a good alternative material for river sand [2]. R.Kandasamy reported that with addition of domestic plastic fibres in

    Chat Online
  • EXPERIMENTAL INVESTIGATION ON CONCRETE BY

    2019-4-21 · aggregate was adopted for investigation. The investigation indicates that crushed stone dust has vast potential as fine aggregate in concrete construction. Crusher dust not only reduces the cost of construction but also helps reduce the impact on environment by consuming the material hitherto considered as a waste product with few applications.

    Chat Online
  • Stone Dust in Concrete: Effect on Compressive Strength

    2017-8-24 · stone dust as fine aggregate in concrete it is found that there is increase in compressive, flexural and tensile strength of concrete (Nagpal et al., 2013). It has been observed that 40% replacement of fine aggregate with stone dust is adaptable (Franklin et al., 2014). It was observed that the replacement of

    Chat Online
  • Utilization of Stone Dust as Fine Aggregate Replacement

    2015-4-30 · of fine aggregate with stone dust. The results shows strength of concrete increases within 5-12 percent up to 50 percent replacement of fine aggregate. And at 60 percent stone dust in concrete the maximum value of compressive strength is obtained which is 17 percent more than referral concrete (concrete with zero percent stone dust).

    Chat Online
  • AN EXPERIMENTAL INVESTIGATION ON THE STRENGTH

    2017-11-15 · 20% replacement of cement with Stone Dust and 50% replacement of fine aggregate with Crushed fine aggregate. Key Words: Stone Dust, Crushed fine aggregate, quarry dust, Flexural Strength, concrete. 1.INTRODUCTION Cement is the most active component of concrete usually has the greatest unit cost, its selection and proper use are

    Chat Online
  • PARTIAL REPLACEMENT OF CEMENT BY QUARRY DUST

    2019-4-21 · corrosion resistance behavior of inhibitors in concrete containing quarry dust as fine aggregate,” Journal of Engineering and Applied Sciences, vol. 6, no. 11, pp. 124–135, 2011. [12] R. P. Nanda, A. K. Das, and N. Moharana, “Stone crusher dust as

    Chat Online
  • Investigation of the mechanical strength of stone dust and ...

    2021-1-1 · The stone dust passing through 4.75 mm sieve has been utilized as the replacement of natural sand. This dust was obtained from a local stone crusher plant. The stone dust in the present study. Similar to the sand, the silt has also been tested for various characteristics in the laboratory. Table 4 shows the results of the laboratory testing.

    Chat Online
  • Study On Concrete With stone Dust - Seminars Topics

    2017-7-1 · The investigation done by Student on the use of stone crusher dust in concrete as an alternative to fine aggregate are presented in this report. Standard concrete cubes (150 mm), cylinders (150x300 mm), prisms (100x100x500 mm) as well as beams (120x150x1350 mm) were tested. The physical properties of stone dust and its influence on the strength ...

    Chat Online
  • Utilization of Stone Dust as Fine Aggregate Replacement

    2015-4-30 · of fine aggregate with stone dust. The results shows strength of concrete increases within 5-12 percent up to 50 percent replacement of fine aggregate. And at 60 percent stone dust in concrete the maximum value of compressive strength is obtained which is 17 percent more than referral concrete (concrete with zero percent stone dust).

    Chat Online
  • Investigation on ceramic waste and stone dust as

    2020-8-27 · [6] M. V. Reddy, “Investigations on stone dust and ceramic scrap as aggregate replacement in concrete,” International Journal of Civil & Structural Engineering, vol. 1(3), pp. 661-666, 2010 [7] R. P. Nanda, A. K. Das, and N. C. Moharana, “Stone crusher dust as a fine aggregate in Concrete for paving

    Chat Online
  • Experimental Investigation on the Concrete as a Partial ...

    2015-12-8 · study on the concrete by using stone dust and brick dust on the mechanical properties of the concrete. In this experimental study two types admixtures are used in preparation of concrete mix. Stone dust and brick dust are added from 0% to 25% by weight of fine aggregate with increment of 5%. A comparative analysis has been carried

    Chat Online
  • Experimental Study on Concrete and Cement Plaster

    2017-3-28 · experimental investigation on quarry dust concrete with chemical admixtures. An attempt has been made to replace ... the possibility of using crushed stone dust as fine aggregate partially or fully with different grades of concrete ... broken into the small pieces crusher dust is formed. It is gray in color and it is like fine aggregate.

    Chat Online
  • Investigations on Various Concrete Properties by ...

    2021-7-23 · Investigations on Various Concrete Properties by Replacement of Fine Aggregate with Stone (Quarry) Dust Y.Anand Babu School of Civil & Environmental Engineering, Jimma University, Jimma, Ethiopia [email protected] Asst. Prof.

    Chat Online
  • EFFECT OF REPLACING SHARP SAND WITH STONE DUST

    2021-4-19 · Concrete is very variable material, having a wide range of strengths and stress-strain curve. Concrete composite material whose basic properties are related to the characteristic of constituent element, especially the aggregate. This research aimed to investigate the effect of replacing sharp sand with stone dust as an alternative to only river sand.

    Chat Online
  • EFFECT OF CONTENTS OF MICROFINES IN CRUSHED

    2019-2-26 · The locally obtained quarry dust was used as a partial replacement for fine aggregate in this investigation. The sample of quarry dust (Fig. 4) was analyzed and the results of sieve analysis are presented in Table 2. Figure 4 also presents graphical results of an XRD analysis of a sample of unwashed crushed sand obtained from Mumbai.

    Chat Online
  • PARTIAL REPLACEMENT OF CEMENT BY QUARRY DUST

    2019-4-21 · corrosion resistance behavior of inhibitors in concrete containing quarry dust as fine aggregate,” Journal of Engineering and Applied Sciences, vol. 6, no. 11, pp. 124–135, 2011. [12] R. P. Nanda, A. K. Das, and N. Moharana, “Stone crusher dust as

    Chat Online
  • Investigation of the mechanical strength of stone dust and ...

    2021-1-1 · The stone dust passing through 4.75 mm sieve has been utilized as the replacement of natural sand. This dust was obtained from a local stone crusher plant. The stone dust in the present study. Similar to the sand, the silt has also been tested for various characteristics in the laboratory. Table 4 shows the results of the laboratory testing.

    Chat Online
  • 7 III March 2019 doi.org/10.22214/ijraset.2019

    C. Fine Aggregate The naturally available river sand used as fine aggregate. The fine aggregate Zone II passed through 4.75 mm and retained on 150 µ sieve is used confirming to the requirements of IS: 383-2016. D. Stone Dust Stone dust

    Chat Online
  • EXPERIMENTAL INVESTIGATION ON CONCRETE BY

    2019-4-21 · aggregate was adopted for investigation. The investigation indicates that crushed stone dust has vast potential as fine aggregate in concrete construction. Crusher dust not only reduces the cost of construction but also helps reduce the impact on environment by consuming the material hitherto considered as a waste product with few applications.

    Chat Online
  • Study On Concrete With stone Dust - Seminars Topics

    2017-7-1 · The investigation done by Student on the use of stone crusher dust in concrete as an alternative to fine aggregate are presented in this report. Standard concrete cubes (150 mm), cylinders (150x300 mm), prisms (100x100x500 mm) as well as beams (120x150x1350 mm) were tested. The physical properties of stone dust and its influence on the strength ...

    Chat Online
  • An Experimental study on Crushed Stone Dust as Fine ...

    2018-1-1 · The Narmada River sand is used as NS. (ii) Crushed Stone dust is a fine material formed during the process of conversion of rock into aggregate and has particle size ranging from 4 mm to dust size (> 0.075mm). It was procured from stone crusher plant producing 20 mm downgraded aggregate, M/s Maa Pitambara Stone situated at Neelbad, Bhopal (India).

    Chat Online
  • Study on Partial Replacement of Fine Aggregate by Quarry ...

    2017-3-8 · Earlier investigation indicates that stone crusher dust has a good potential as fine aggregate in concrete construction. Crusher dust not only reduces the cost of construction but also helps to reduce the impact on environment by consuming the material generally considered as a waste product with few applications. LITERATURE SURVEY. Mini Soman ...

    Chat Online
  • [PDF] Effective Utilization of Crusher Dust in Concrete ...

    Hence the present investigation was taken up with a view to verify the suitability, feasibility and potential use of crusher dust, a waste product from aggregate crushing plant in concrete mixes, in context of its compressive strength and workability and in terms of slump, compacting factor, flow table and modified flow respectively.

    Chat Online
  • Geo Polymer Concrete with the Replacement of Granite ...

    2020-4-1 · concrete with stone dust as fine aggregate, draws the following conclusions-The concrete cubes with crusher dust developed about 17% higher strength in compression, more split tensile strength and 20% more flexural strength (Modulus of Rupture) than the Concrete cubes/beams with river sand as fine aggregate.

    Chat Online
  • PARTIAL REPLACEMENT OF CEMENT BY QUARRY DUST

    2019-4-21 · corrosion resistance behavior of inhibitors in concrete containing quarry dust as fine aggregate,” Journal of Engineering and Applied Sciences, vol. 6, no. 11, pp. 124–135, 2011. [12] R. P. Nanda, A. K. Das, and N. Moharana, “Stone crusher dust as

    Chat Online
  • EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

    2018-11-5 · to study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete. 1.2 NEED FOR INVESTIGATION Quarry Dust These residues are generally less than 1% aggregate production in the normal concrete. The introduction of quarry dust for mixing is limited due to its high fineness.

    Chat Online
  • Investigation of the mechanical strength of stone dust and ...

    2021-1-1 · The stone dust passing through 4.75 mm sieve has been utilized as the replacement of natural sand. This dust was obtained from a local stone crusher plant. The stone dust in the present study. Similar to the sand, the silt has also been tested for various characteristics in the laboratory. Table 4 shows the results of the laboratory testing.

    Chat Online
ZhengZhou N-CAI Corporation © 2020 Copyright.Crusher